3412C Generator Set

3412C Generator Set

Caterpillar is leading the power generation marketplace with Power Solutions engineered to deliver unmatched flexibility, expandability, reliability, and cost-effectiveness.

Bore
5.4 in
Displacement
1648.86 in3
Stroke
6 in
Aspiration
TA

Engine Specifications

Bore
5.4in
Displacement
1648.86in3
Stroke
6in
Aspiration
TA
Fuel System
Pump and Lines
Aspiration
TA
Fuel System
Pump and Lines
Bore
5.4in
Displacement
1648.86in³
Stroke
6in
Engine Model
3412C TA, V-12, 4-Stroke Water-Cooled Diesel
Compression Ratio
13:00:01
Governor Type
ADEM™ A5

Generator Set Specifications

Minimum Rating
591 ekW
Maximum Rating
800 ekW
Voltage
208 to 600 Volts
Frequency
60 Hz
Speed
1800 RPM

Generator Set Configurations

Emissions/Fuel Strategy
Low Fuel Consumption

Standard Equipment:

  • Air Inlet System
    • Air cleaner, single element canister type
  • Control Panel
    • EMCP 4.2
    • Controls:
    • Run / Auto / stop Control
    • Speed Adjust
    • Voltage Adjust
    • Engine Cycle Crank
    • Emergency stop pushbutton
    • Digital Indicator for:
    • RPM
    • DC volts
    • Operating hours.
    • Oil pressure (psi, kPa or bar).
    • coolant temperature
    • Volts (L-L & L-N)
    • Frequency (Hz)
    • Amps (per phase & average)
    • Power Factor (per phase & average)
    • Warning shutdowns:
    • Low Oil pressure
    • High coolant temperature
    • Overspeed
    • Emergency stop
    • Failure to start (overcrank)
    • Low coolant temperature
    • Low coolant level
    • Communications:
    • Customer data link (Modbus RTU)
    • Accessory module data link
    • Serial annunciator module data link
    • Compatible with the following optional modules:
    • Digital I/O module
    • Local annunciator
    • Remote CAN annunciator
    • Remote Serial annunciator
    • Generator temperature monitoring module
  • Cooling System
    • Radiator with guard (sized for 50 degrees C)
    • Fan and belt guards
    • Coolant drain line with valve
    • Caterpillar extended life coolant
  • Exhaust System
    • Stainless steel exhaust flex with ANSI style outlet flange
  • Fuel System
    • Primary and secondary fuel filters
    • Fuel priming pump
    • Water separator
  • Generator And Attachments
    • SR4B self excited
    • Class H insulation
    • Class F temperature rise
    • 12 Lead
    • VR6B Voltage Regulator
    • 3 Phase sensing
    • 2:1 Volts / Hz
    • Reactive droop
    • Busbar termination
  • Governing System
    • Cat electronic governor
  • Lube System
    • Lubricating oil
    • Oil filter
    • Oil drain line with valve
  • Mounting System
    • Base, formed steel with linear vibration isolators between base and engine-generator
  • Starting / Charging System
    • 45 Amp charging alternator
    • Fuel shutoff solenoid
    • 24 Volt starting motor
    • Battery with rack, cables
  • General
    • Paint - Caterpillar Yellow except rails and radiators gloss black

Optional Equipment:

  • Air Inlet System
    • Air cleaner - dual element
    • Air cleaner - heavy element
    • Air cleaner - open element
  • Certificates
    • EU Certification
  • Circuit Breakers
    • 3 Pole Circuit Breakers with shunt trip
    • 4 Pole circuit breakerswith shunt trip
    • Power terminal strips
  • Control Panel
  • Cooling System
    • Radiator duct flange
    • Jacket water heater
    • Radiator removal
  • Exhaust System
  • Fuel System
    • Manual Fuel transfer pump
    • Automatic fuel transfer system
  • Generator And Attachments
    • Anti-condensation heater
    • Internal excitation (IE)
    • Permanent magnet excitation (PMG)
    • Oversize and premium generators
  • Governing System
    • Electronic load share
  • Lube System
    • Manual sump pump
  • Mounting System
  • Special Tests / Reports
    • PGS test report @ 1.0 power factor
    • PGS test report @ 0.8 power factor
    • Factory witness test
  • Starting / Charging System
    • Battery chargers
    • Battery removal
    • Oversize battery
    • Battery disconnect switch
    • Heavy duty starting system
  • Enclosures
    • Weather protective enclosure (WP)
    • Sound attenuated enclosure (SA)
    • DC Lighting package