801-974-0511

D100 GC Generator Set

  • Home »
  • New Powers » D100 GC Generator Set
    Order Parts Request Service

    D100 GC Generator Set

    Download Product Brochure
    Email/Share
    Minimum Rating
    100 ekW
    Maximum Rating
    100 ekW
    Emissions/Fuel Strategy
    U.S. EPA Cert., Tier 3
    Voltage
    208 to 600 Volts

    Generator Set Specifications

    Minimum Rating
    100 ekW
    Maximum Rating
    100 ekW
    Emissions/Fuel Strategy
    U.S. EPA Cert., Tier 3
    Voltage
    208 to 600 Volts
    Frequency
    60 Hz
    Speed
    1800 rpm
    Duty Cycle
    Standby

    Engine Specifications

    Engine Model
    C4.4, In-line 4, 4-cycle diesel
    Bore
    4.1in
    Stroke
    5in
    Displacement
    269in³
    Compression Ratio
    16.7:1
    Aspiration
    Turbocharged
    Fuel System
    Common Rail
    Governor Type
    Mechanical, ADEM™A4

    Generator Set Dimensions

    Length - Maximum
    82.6in
    Width - Maximum
    43.3in
    Height - Maximum
    52.9in
    Dry Weight - Genset (maximum)
    2222lb

    Standard Equipment:

    • Air Inlet System
      • Air cleaner; light duty with disposable element
      • Air Cleaner
    • Cooling System
      • Coolant drain line with valve
      • Radiator and cooling fan with guards
      • Caterpillar extended life coolant
      • Fan drive, battery charging alternator drive
    • Control Panel
      • GCCP 1.2 Control panel
    • Exhaust System
      • Stub pipe, gaskets, raincap and SAE exhaust flange for customer use - shipped loose
    • Fuel System
      • Standard open set fuel tank / base supplied base, formed steel with single wall integral 24-hour fuel tank
    • Generator
      • Circuit breaker, IEC, 3 pole, mounted in tower panel
      • IP23 protection
      • Tower panel, IP22, bottom cable entry
      • 12 Leads
      • Voltage regulator (single phase sensing)
      • Segregated low voltage (AC/DC) wiring panel
    • Governing System
      • Mechanical and electrical governing system - model dependent
    • Lube System
      • Lubricating oil
      • Oil drain line with valve
    • Mounting System
      • Termination points for coolant and lube oil drain lines
      • Captive linear vibration isolators between base and engine-generator
      • Includes lifting provision and drag points
    • Starting/charging System
      • Batteries
      • 24V battery with rack and cables
    • General
      • Engine and alternator pre-paint, Caterpillar Yellow

    Optional Equipment:

    • Alternator System
      • Anti-condensation heater
      • 3 phase sensing
      • Permanent magnet
      • R frame auxilliary winding
      • Quadrature droop kit
    • Circuit Breakers
      • Circuit Breaker Upgrades - 4 Pole circuit reaker to 250A, 400A and 630 A
    • Cooling System
      • Coolant heater
      • Low coolant temp alarm
      • Low coolant level shutdown
    • Control Panel Options
      • Earth fault (2 wire only)
      • Control panel heater
      • GCCP 1.2 control panel
      • Volt free contacts
      • Emergency stop with key
      • Voltage adjust potentiometer
      • Overload shutdown via breaker
      • Panel mounted audible alarm
      • Battery charger
      • Earth leakage (2 wire only)
      • Speed adjust potentiometer
    • Enclosures
      • Sound attenuated Level 2 enclosure
    • Fuel System
      • Low fuel level alarm
      • Bunded fuel tank
      • Low fuel level shutdown
      • High fuel level alarm
    • Mounting Options
      • Battery removal
      • Electronic governor
      • Industrial silencer
      • External single point lift - enclosure
      • Silencer installation kit
    • Special Packing/inspectons For Shipment
      • PGS test report @ 0.8 power factor
      • PGS test report @ 1.0 power factor
    • General - Accessories / Miscellaneous
      • Packing case - canopied set
      • Packing case - compact set
      • Stone guards / rad trans flange